Green Gene

greengene.jpg
Green Gene - My 2003 Wrangler X (TJ)

Named after Eugene the Jeep
Popeye presents Eugene, the Jeep (Dec. 13, 1940) (youtube)

Specifications

TJ

Wheelbase = 93.4“
Overall length = 155.4”
Overall width = 66.7“
Overall height (soft top) = 70.8”
Track width = 57.8 - 58.5“
Turning diameter = 33.5'-36'
Curb weight = 3,092-3,832 lbs
Cargo capacity = 55.7 cu ft.
Fuel capacity = 15 - 19 gal (19 gal became standard during the 99 model year)
Towing capacity = 1,000 lbs 4cyl / 2,000 lbs 6 cyl
Ground clearance (at axle) = 8.7”-9.2“ front / 8.6”-9.1“ rear
Approach angle = 42.2*
Departure angle = 31.5*
Breakover angle = 22.3*
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/

Engine

4.0L (AMC 242) SMFI I6 “Power Tech” AMC_Straight-6_engine#4.0
4.0L I-6 242 cu in - 2000-2006
* 190 hp @ 4,600 RPM
* 235 ft/lbs @ 3,200 RPM
* OHV
* Sequential port fuel injection
* 2 valves per cylinder
* Compression ratio = 8.80:1
* Distributor-less ignition
* Redesigned cylinder head
* Redesigned 2 piece exhaust manifold
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/

Transmission

New Venture Gear NV3550 New Venture Gear 3500 transmission
* 5 speed manual
* Used with 6 cyl models
* 10 spline input
* 23 spline output
* Ratios:
1st - 4.01
2nd - 2.33
3rd - 1.39
4th - 1.00
5th - 0.78
Rev - 3.57
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/

Transfer Case

NV231 Command-Trac - 1997-2006 Jeep four-wheel-drive systems#Command-Trak 2
* Used on all TJs except Rubicon models
* 2.72:1 Low range
* Slip yoke
* Gear driven speedometer signal
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/

Front Axle

Dana M30/181MM Dana 30
* Front axle used on all TJs except the Rubicon model
* Stock gear ratio options = 3.07, 3.55, 3.73, 4.10, 4.56
* Carrier break = 3.55 / 3.73
* Open carrier - no Trac-Lok limited slip option
* Ring gear diameter = 7.2”
* Ring gear bolts = (10) 3/8 x 20 RH
* Low pinion (short pinion)
* Pinion shaft diameter = 1.376“
* Pinion shaft spline count = 26
* Axle shaft diameter = 1.18”
* Axle shaft spline count = 27 both inner and outer
* Axle shaft u-joints = 5-760x / 5-297x
* WMS-WMS = approximately 60.5“
* 5 on 4.5” bolt pattern
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/
Fitted Axle Ratio: 3.07

Rear Axle

Dana M35/194MM Dana 35
* Standard rear axle used on all TJs except the Rubicon model
* Stock gear ratio options = 3.07, 3.55, 3.73, 4.11, 4.56
* Carrier break = 3.31 / 3.55
* Optional Trac-Lok limited slip differential
* Ring gear diameter = 7.5625“
* Ring gear bolts = (8) 3/8 x 24 RH - NOTE: 7/16” x 20 RH used on later model TJs
* Low pinion
* Pinion shaft diameter = 1.406“
* Pinion shaft spline count = 26
* Axle shaft diameter = 1.18”
* Axle shaft spline count = 27
* WMS-WMS = approximately 60.5“
* 5 on 4.5” bolt pattern
* Rubber pressed-in fill plug
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/
Fitted Axle Ratio: 3.07

Exterior Accessories

Color: Shale Green Metallic

Fender Flares

* 3.25“ - used on all SE, X (except those listed under 4.25”), and Sport models
~ http://www.jeepforum.com/forum/f9/stock-tj-specifications-452871/

Bestop Supertop

Side Steps

Wheels

Original: (4) 15“ x 7” full face steel wheels
Fitted: MB Wheels 70's 15 x 8“ 5-114.3

Tires

Original: P215/75R15 All Terrain SBR RBL “Wrangler” tires
Fitted: BF Goodrich All-Terrain T/A KO 31x10.5/R15 109 S (bfgoodrich)

Interior Accessories

Sony CDX-GT660UP

Kicker Speakers

References